AX-2024-005346 · Tirzepatide · SIG lot SIG-2404-6658

Section 1

Results

Measured against the index acceptance specification for the incretin analogues and co-agonists class. A specification is a decision the index made; a result is a measurement. See where each threshold came from.

Parameter	Method	Result	Unit	Index spec
Purity	RP-HPLC, 35 min gradient, 214 nm	97.55	% area	≥ 97.0	PASS
Total impurities	RP-HPLC, sum of reported peaks	2.45	% area	≤ 3.0	PASS
Largest single impurity	RP-HPLC — C20 diacid mono-amide	1.58	% area	≤ 1.00	FAIL
Identity — theoretical monoisotopic mass	calculated from molecular formula	4810.4103	Da	—	NOT TESTED
Identity — observed monoisotopic mass	LC-MS, high resolution (ESI-TOF/QTOF)	4810.4185	Da	—	NOT TESTED
Mass accuracy	observed vs theoretical	+1.7	ppm	± 15	PASS
Total peptide content	by difference from the gravimetric mass balance	83.27	%w/w	—	NOT TESTED
Target-compound content	total peptide content × purity	81.23	%w/w	—	NOT TESTED
Gross fill (as weighed)	five-place balance, under nitrogen	38.00	mg	30 mg declared	NOT TESTED
Recovered target peptide	gross fill × target content	30.867	mg	30 mg claim	NOT TESTED
Recovery against label claim	recovered ÷ claim	102.9	%	90.0 – 110.0	PASS
Water content	Karl Fischer, coulometric, duplicate	7.85	%	≤ 8.0	PASS
Counter-ion (TFA)	anion-exchange ion chromatography	8.61	%	≤ 12.0	PASS
Residual solvent + inorganic residue	estimated — see /methods/residual-solvents-q3c/	0.27	%	—	NOT TESTED
Endotoxin	not ordered on this submission	not determined	—	≤ 5.0	NOT TESTED
Sterility	not ordered on this submission	not determined	—	no growth	NOT TESTED
Appearance	visual, diffuse light, black and white background	White cake, partially collapsed	—	white to off-white intact cake	FAIL
Reconstitution clarity	reconstituted per submitter procedure	Clear, colourless, no visible particulates	—	clear, no visible particulates	PASS
pH (reconstituted, 1 mg/mL)	potentiometric, two-point calibration	3.36	—	2.5 – 8.0	PASS
Retention time (observed)	RP-HPLC, 35 min gradient	22.80	min	22.91 ± 0.45 (normalised)	PASS
Peak asymmetry (10 % height)	Ph. Eur. 2.2.46	0.86	—	0.80 – 1.50	PASS
Plate count, main peak	N = 5.54 (t/w½)²	39,355	—	≥ 20,000	PASS
Resolution to nearest impurity	vs [D-Aib13]-diastereomer	0.47	—	no index criterion	REPORTED

Section 2

Chromatogram and peak integration

The figure is drawn from the table. It is not an independent illustration — if a number in the table changed, the trace would change with it.

Figure 1. RP-HPLC trace, 35 min gradient, 214 nm. Drawn from the peak-integration table below: peak positions are the reported retention times, peak areas are the reported area percentages, peak widths follow the reported plate count of 39,355, and skew follows the reported asymmetry factor of 0.86. Baseline noise is seeded from the report ID and is illustrative. The lower panel is the same trace at a stated vertical expansion with the slow gradient drift subtracted, because at full scale a 1.58 % impurity against a 97.55 % main peak is a line two pixels tall; the main peak runs off-scale there by design.

#	Peak	RT	Area (µV·s)	% area	Δ mass (Da)
1	Tirzepatide — main peak	22.80	4,741,232	97.55	—
2	C20 diacid mono-amide	24.69	76,793	1.58	+0.984
3	truncated (3-39)	21.07	26,732	0.55	-222.112
4	des-Gly deletion (−57 Da)	22.09	6,804	0.14	-57.021
5	des-Aib2 analogue	22.39	3,888	0.08	-85.053
6	tirzepatide dimer	27.44	3,402	0.07	+4810.410
7	[D-Aib13]-diastereomer	22.58	1,458	0.03	0.000
Closure check — purity + Σ impurities				100.00	CLOSES

Reporting threshold 0.05 % area. Peaks below it are not reported and are therefore excluded from the total, which overstates purity by their sum — see peak integration.

Section 3

Mass spectrum and identity

Theoretical monoisotopic mass 4810.4103 Da, computed from C225H348N48O68. All ppm figures on this site are against monoisotopic values — see why that matters.

Figure 2. ESI charge-state envelope, high-resolution instrument. Sticks are placed at m/z = (M + z × 1.007276)/z for the observed neutral mass of 4810.4185 Da. Sodium (+21.982/z) and potassium (+37.956/z) adducts are shown where the parent charge state exceeds 25 % relative abundance; they are adducts of the same molecule and are not impurities.

Charge	Theoretical m/z	Observed m/z	Δ m/z	Rel. abundance (%)
7+	688.2087	688.2099	0.0012	8.9
6+	802.7423	802.7437	0.0014	51.1
5+	963.0893	963.0910	0.0017	100.0
4+	1203.6099	1203.6119	0.0020	53.8
3+	1604.4774	1604.4801	0.0027	8.3

Section 4

Gravimetric mass balance

Water, counter-ion, residual and total peptide content are exhaustive and mutually exclusive categories. They must account for 100 % of the cake mass. The index closes this to within 0.02 pp and the build asserts it.

Component	Determination	%w/w of cake
Water	Karl Fischer	7.85
Counter-ion (TFA)	ion chromatography	8.61
Residual solvent + inorganic residue	estimated	0.27
Total peptide content	by difference	83.27
Total		100.00 CLOSES

Supplier certificate, as declared

The supplier's own figures for this lot, beside the independent measurement. Divergence is assessed against the batch median, not against this single report — see rule AX-R05.

Figure	Supplier COA	This report	Index note
Purity (% area)	98.41	97.55	divergence +0.83 pp vs batch median
Total impurities (% area)	1.59	2.45
Largest single impurity (% area)	0.71	1.58
Water (%)	7.5	7.85
Counter-ion (%)	not stated	8.61
Peptide content (%w/w)	not stated	83.27
Endotoxin (EU/mg)	not stated	not determined
Method stated on certificate	NO	—	no method section — the result cannot be reconciled against any other

Section 5

Provenance and caveats

Where a sample came from changes the weight of the evidence. The index treats it as a first-class field.

Sample provenance: Laboratory-retained
Evidentiary weight: Provenance documented, selection uncontrolled.
Chain of custody: Laboratory retained sample (−20 °C, 19 d since original receipt) → re-assay.
Assay date: 22 Aug 2024
Submitted to the index: 09 Sep 2024
Laboratory: Nordanalyt Laboratories, Uppsala, Sweden
Method basis: 35 min gradient · high-resolution MS
Verification status: VERIFIED

What this report does not establish

That the material is free of bacterial endotoxin. Endotoxin was not measured. No chromatographic result bears on it.
That the material is sterile. Sterility was not tested.
That any other vial in the same lot has the same composition. One vial was tested. Within-lot vial-to-vial variation in this index has a median of 0.28 pp and a 90th percentile of 0.74 pp.
That any other lot from the same supplier has the same composition. Batch-to-batch variation is larger than within-batch variation for every supplier here.
That the material is suitable for administration to a human or an animal. These are research compounds. No result on this site is a safety assessment and the index takes no position on use.
That the material was manufactured by the supplier that sold it. Contract synthesis is normal in this market and twenty-nine batches in the index fingerprint to a bulk from a different company than the one named on the label.

Section 6

Annotations 2

Signed technical comments from index contributors. Not a discussion forum — annotations question or contextualise the result, and the data team replies where a reply is warranted.

tbu_residual09 Sep 2024

No +56 Da satellite in the envelope, which is the residual-protection signature. Its absence is worth as much as the parent mass being right.

macrolactam09 Sep 2024

For any sequence closed head-to-side-chain, the uncyclised precursor differs by 18 Da and is trivially separable by mass. The envelope on this record shows nothing at that offset.

Section 7

Related records

Same batch — lot SIG-2404-6658 n=11

Report	Lot	Lab	Quarter	Purity %	Water %	Recovery %	Provenance	Result
AX-2024-005342	SIG-2404-6658	Medutest	2024-Q3	97.66	8.11	—	Buyer-sourced	FAIL
AX-2024-005343	SIG-2404-6658	Nordanalyt	2024-Q3	97.68	7.99	98.1	Buyer-sourced	PASS
AX-2024-005344	SIG-2404-6658	VendorInvestigate	2024-Q3	97.51	8.05	94.4	Buyer-sourced	FAIL
AX-2024-005345	SIG-2404-6658	PeptideMeter	2024-Q3	97.49	7.59	—	Supplier-supplied	PASS
AX-2024-005347	SIG-2404-6658	Janoshik	2024-Q3	97.52	7.74	101.6	Buyer-sourced	PASS
AX-2024-005348	SIG-2404-6658	Janoshik	2024-Q3	97.56	7.79	—	Buyer-sourced	PASS
AX-2024-005349	SIG-2404-6658	Janoshik	2024-Q3	97.61	8.41	92.1	Buyer-sourced	FAIL
AX-2024-005350	SIG-2404-6658	Kestrel	2024-Q3	97.79	8.02	93.9	Buyer-sourced	FAIL
AX-2024-005351	SIG-2404-6658	Medutest	2024-Q3	97.60	7.77	106.2	Buyer-sourced	PASS
AX-2024-005352	SIG-2404-6658	Janoshik	2024-Q3	97.58	7.96	—	Buyer-sourced	PASS

Batch rollup and reproducibility assessment →

Cross-sections

Other recent Tirzepatide records in the index.
Report	Supplier	Lot	Lab	Quarter	Purity %	Water %	Recovery %	Provenance	Result
AX-2026-043288	CPC	CPC-2607-L1516	Janoshik	2026-Q3	96.89	5.11	101.1	Laboratory-retained	FAIL
AX-2026-041610	FGP	FGP-2603-L7753	Janoshik	2026-Q3	98.81	2.45	101.0	Buyer-sourced	PASS
AX-2026-041974	AMB	AMB-2603-C5112	Nordanalyt	2026-Q3	98.20	3.41	—	Buyer-sourced	PASS
AX-2026-041975	AMB	AMB-2603-C5112	Medutest	2026-Q3	97.88	3.45	106.9	Laboratory-retained	PASS
AX-2026-041609	FGP	FGP-2603-L7753	Janoshik	2026-Q3	98.52	2.00	98.0	Buyer-sourced	PASS
AX-2026-041978	AMB	AMB-2603-C5112	Janoshik	2026-Q3	97.94	3.57	103.0	Buyer-sourced	PASS
AX-2026-041982	AMB	AMB-2603-C5112	Janoshik	2026-Q3	97.60	4.46	—	Buyer-sourced	PASS
AX-2026-043286	CPC	CPC-2607-L1516	Kestrel	2026-Q3	98.20	4.56	—	Buyer-sourced	PASS

Other recent SIG records in the index.
Report	Compound	Lot	Lab	Quarter	Purity %	Water %	Recovery %	Provenance	Flags	Result
AX-2026-043535	GHRP-2	SIG-2603-6031	Janoshik	2026-Q3	99.12	1.26	105.7	Buyer-sourced	0	PASS
AX-2026-043541	GHRP-2	SIG-2603-6031	PeptideMeter	2026-Q3	99.06	2.08	107.4	Buyer-sourced	1	MARGINAL
AX-2026-043539	GHRP-2	SIG-2603-6031	Janoshik	2026-Q3	98.95	1.74	100.4	Buyer-sourced	1	FAIL
AX-2026-043534	GHRP-2	SIG-2603-6031	Medutest	2026-Q3	99.11	2.15	89.8	Buyer-sourced	1	MARGINAL
AX-2026-043542	GHRP-2	SIG-2603-6031	VendorInvestigate	2026-Q3	99.05	1.43	—	Buyer-sourced	1	FAIL
AX-2026-043543	GHRP-2	SIG-2603-6031	Janoshik	2026-Q3	99.38	1.70	98.6	Buyer-sourced	0	PASS
AX-2026-043544	GHRP-2	SIG-2603-6031	PeptideMeter	2026-Q3	99.57	1.51	105.4	Buyer-sourced	0	PASS
AX-2026-043538	GHRP-2	SIG-2603-6031	Kestrel	2026-Q3	98.93	1.72	—	Buyer-sourced	0	FAIL